Contact your DeVilbiss equipment provider should you have any questions. Visual and audible alarms indicate if the device is not meeting specifications or a failure has been detected. Use disinfectants safely Always read the label and product information before use, Always wear personal protective equipment when performing this procedure Use suitable gloves and safety glasses Cover exposed skin on arms to prevent accidental contact with a bleach solution that has been applied to the concentrator. Do not use the device or accessories in an environment with electromagnetic equipment such as CT scanners, Diathermy, RFID and electromagnetic security systems (metal detectors) as it may cause unacceptable risk to the patient or damage to the oxygen concentrator. Do not bring the device or accessories into a Magnetic Resonance (MR) environment as it may cause unacceptable risk to the patient or damage to the oxygen concentrator or MR medical devices.

Avoid over-saturating the cabinet seams so that no solution residue builds up in these areas. All rights reserved. The expected service life of the unit, and in particular the sieve beds and compressor, may vary based on the operating environment, storage, handling and the frequency and intensity of use. We have grown from typical wheelchair accessory equipment, to a full line of wheelchairs made by Quickie. Contact your DeVilbiss provider immediately. Please take time to familiarize yourself with your DeVilbiss oxygen concentrator before operating, Transfer Caddy DeVilbiss 525DD-650 Bubble Humidifier Salter Labs 7600 or equivalent. 2. 1 . After the recommended exposure time, all surfaces of the concentrator should be wiped with a clean lint-free cloth dampened with drinking quality water no warmer than room temperature. If you feel discomfort or are experiencing a medical emergency while undergoing oxygen therapy, seek medical assistance immediately to avoid harm. When the unit is turned On, all three lights (Service Required, Low Oxygen, and Normal Oxygen) on the front panel will illuminate briefly and an audible signal will briefly alarm confirming that the LEDs and audible signal are functioning properly. Essential PerformanceEssential Performance of the Oxygen Concentrator is to deliver a continuous flow of oxygen-enriched gas. DANGEROxygen causes rapid burning. A flow setting other than prescribed may affect the patient therapy. Mild dish soap (2 tbsp) and warm water (2 cups). All Rights Reserved. The oxygen concentrator is used in home-type environments, homes, nursing homes, patient care facilities, etc. 4. EKd^/T=pv"P}h;Q85Zq Replacement Cooling Fan - Fits Many Models, Portable Concentrator Parts & Accessories. Audible low-frequency vibration sound is detected . Repeat these steps until the flow meter ball drops to zero. Also, do not forget that we have a full line of replacement filters for every make and model of Oxygen Concentrator and also CPAP and BIPAP machines! Auxiliary Oxygen Port (Serial numbers starting with R, N, or B): Your concentrator is equipped with an auxiliary oxygen port that can be used to fill oxygen cylinders with an FDA-cleared cylinder filling device that is designed to use oxygen from a concentrator to fill a cylinder. On 230 volt units, also check the mains connection on the back of the unit . devilbiss concentrator 525ds dotmed 5. Proper cleaning is discussed in the Caring For Your Concentrator section on page 8. Keep body parts a minimum of 32 (81.2 cm) away from this area. If such use is necessary, this equipment and the other equipment should be observed to verify that they are operating normally. Before attempting any cleaning procedures, turn the unit Off.. Oxygen Tubing Connection With Humidification:If your physician has prescribed an oxygen humidifier as part of your therapy, follow these steps (If using a prefill, go to step b. You may need a new capacitor! The yellow Low Oxygen light is on and the intermittent audible signal is sounding .

Attach the appropriate oxygen accessories to the oxygen outlet. WARNINGTo avoid electric shock, do not plug the concentrator into an AC outlet if the concentrator cabinet is broken. If bactericidal cleaning is required, a non-alcohol-based product should be used to avoid inadvertent damage. Follow disinfectant manufacturers instructions. Detach cannula or face mask. To avoid electric shock, do not plug the concentrator into an AC outlet if the concentrator cabinet is broken. Use of this device at an altitude above 13,123 feet (4000 meters) or above a temperature of 95F (35C) or greater than 93% relative humidity may affect the flow rate and the percentage of oxygen and consequently the quality of the therapy. 3 . NOTE There is no portion of the gas pathways through the concentrator that could be contaminated with body fluids under normal conditions.The device patient connection may unintentionally become contaminated with expired gases for a single fault condition i.e., a hose internal to the device becomes disconnected. Service LifeThe expected service life of the 525 is 5 years of operation when used in accordance with all manufacturer guidance for safe use, maintenance, storage, handling and general operation. devilbiss oxygen concentrator repair service concentrators refurbished The disposal of infectious accessories (e.g. The use of a fire stop device as part of the oxygen accessories is optional and is not contraindicated for use with this device. Detach the humidifier from the oxygen outlet. Dispose of all accessories that are not suitable for reuse This includes but may not be limited to the oxygen tubing, tubing connectors, nasal cannula and/or mask, oxygen outlet connector, and humidifier bottle. The following troubleshooting chart will help you analyze and correct minor oxygen concentrator malfunctions. Check power cord connection at the wall outlet . Check the exhaust area and make sure there is nothing restricting the unit exhaust . A . endobj Contact your home care provider. Dry the unit with a dry, clean lint-free cloth. The use of this website is subject to terms and conditions. DeVilbiss Oxygen Concentrator Filters include the Bacteria Filter, 515 Filter, Cabin Filter, Intake Filter, Extended Life Intake Filter, and Compressor Filter. Do not smoke while your oxygen concentrator is operating, or when you are near a person utilizing oxygen therapy. If the device is within specification, the extended life intake bacteria filter does not need to be replaced between patients. Make sure it is securely tightened. Heavy soil should be removed with a clean lint-free cloth dampened with water. Before attempting any cleaning procedures, turn the unit Off.. Do not leave the nasal cannula or mask on bed coverings or chair cushions if the oxygen concentrator is turned on but not in use. 2022, Quickie-Wheelchairs.com offered by SouthwestMedical.com, LLC. Keep the oxygen concentrator and cannula at least 2 m (6.5 feet) from hot, sparking objects or naked sources of flame. Improper use of the power cord and plugs can cause a burn, fire or other electric shock hazards. Wrap the cannula tubing over the ears and position in front of body (Figure 4). ): NOTE Your physician has prescribed either a nasal cannula or a face mask. devilbiss oxygen concentrator repair service concentrators refurbished Unapproved filters are used with the unit.

CAUTIONUse of harsh chemicals (including alcohol) is not recommended. If unable to leave the room, you must wait 10 minutes after you have turned off the oxygen concentrator before smoking. Supplemental oxygen is not addictive. Check the flow meter to make sure that the flow meter ball is centered on the line next to the prescribed number of your flow rate. Press the power switch to the On position. The device and accessories have not been evaluated for safety in an MR environment. If proper flow is restored, check oxygen tubing for obstructions or kinks. Do not remove the concentrator cabinet. 1. Over 2,500,000 satisfied customers since 2000, 7 FDA Approved Air Purifiers for Covid-19. This device contains an alarm system that monitors the state of the device and alerts of abnormal operation, loss of essential performance or failures. Blocked or defective cannula, face mask, or oxygen tubing . DeVilbiss Oxygen Concentrator Filter Replacements, Serving more than 2,500,000 satisfied customers since 2000, Vitality Medical7910 South 3500 East Suite CSalt Lake City, Utah 84121. Some electromagnetic sources may not be apparent, if you notice any unexplained changes in the performance of this device, if it is making unusual or harsh sounds, disconnect the power cord and discontinue use. Each component is also quality tested to make sure that without a doubt it will work at or above manufacturer specifications. A mask or any nasal cannula can be used with continuous flow delivery and may be sized according to your prescription as recommended by your homecare provider who should also give you advice on the proper usage, maintenance and cleaning. Do not allow open flames within 2 m (6.5 feet) of the oxygen concentrator or any oxygen-carrying accessories. 2 . Indications For UseThe DeVilbiss Oxygen Concentrator is intended for use as an oxygen concentrator to provide supplemental low flow oxygen therapy in the home, nursing homes, patient care facilities, etc. Before operating your unit, always check to be sure the filter door vents (located on the back of your unit) are clean. Is your Oxygen Concentrator rattling around? Your email address will not be published. You may need some quality replacement Motor Vibration mounts!

Getting your DeVilbiss 5 Liter Oxygen Concentrator back into working condition is our top priority at Quickie Wheelchairs. Unit operates . Check filter door vents and ensure that the openings are not blocked. This warranty shall be voided, and DeVilbiss shall be relieved of any obligation or liability if: THERE IS NO OTHER EXPRESS WARRANTY IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE,ARE LIMITED TO THE DURATION OF THE EXPRESS LIMITED WARRANTY AND TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES AREEXCLUDED THIS IS THE EXCLUSIVE REMEDY AND LIABILITY FOR CONSEQUENTIAL AND INCIDENTAL DAMAGES UNDER ANY AND ALL WARRANTIES AREEXCLUDED TO THE EXTENT EXCLUSION IS PERMITTED BY LAW SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS,OR THE LIMITATION OR EXCLUSION OF CONSEQUENTIAL OR INCIDENTAL DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. Replace if necessary . If bactericidal cleaning is required, a non-alcohol based product should be used to avoid inadvertent damage. Although the concentrator filters the oxygen in a room, it will not affect the normal amount of oxygen in your room. The oxygen will make the materials flammable. The cabinet should only be removed by a qualified DeVilbiss technician. Turn your unit Off. Switch to your reserve oxygen system and contact your DeVilbiss provider immediately. The cabinet should only be removed by a qualified DeVilbiss technician. Attach the oxygen tubing directly to the humidifier bottle outlet fitting (Figure 3). Your physician prescribed supplemental oxygen for you because you are not getting enough oxygen from room air alone. Contact your home care provider. Oxygen makes it easier for a fire to start and spread. Position your unit on a flat surface at least 6 inches (16 cm) from walls, draperies or any other objects that might prevent the proper flow of air in and out of your oxygen concentrator. Use only spare parts recommended by the manufacturer to ensure proper function and to avoid the risk of fire and burns. Ensure the mains power cord is fully inserted into the concentrator connector (230-volt units) and the power cord plug is completely inserted into a fully functioning AC wall outlet. This device contains electrical and/or electronic components that must be recycled per EU Directive 2012/19/EU-Waste Electrical and Electronic Equipment (WEEE). WARNINGWhen using the Transfer Caddy with a Transfill device, always keep the system on a flat surface. Allow 15 minutes for the oxygen concentrator to reach stated performance. OxygenPlus Medical 2019 Powered by Shopify, Devilbiss Oxygen Concentrator Replacement Parts.

NOTE (only 115-volt units) The plug on the DeVilbiss oxygen concentrator has one blade wider than the other. After use of the device, please return the device to the provider for disposal. Clean the exterior of the concentrator with a clean lint-free cloth. Position your unit near an electrical outlet in the room where you spend most of your time. Disassemble the system prior to moving. The unit separates oxygen from room air which allows high-purity supplemental oxygen to be delivered to you through the oxygen outlet. The cabinet should only be removed by a qualified DeVilbiss technician. Turn the oxygen concentrator off when not in use to prevent oxygen enrichment. Turn your unit Off . Switch to your reserve oxygen system and contact your DeVilbiss provider immediately . Vitality Medical. As a precaution, your DeVilbiss provider may supply you with a reserve oxygen system. Unauthorized parts or components (i.e., regenerated sieve material) are used to repair or alter the equipment. Yellow Low Oxygen light below an acceptable oxygen level. F Red Service Required light is on and an intermittent audible signal is sounding. The oxygen delivery setting has to be determined for each patient individually with the configuration of the equipment to be used, including accessories.

Some electromagnetic sources may not be apparent, if you notice any unexplained changes in the performance of this device, if it is making unusual or harsh sounds, disconnect the power cord and discontinue use. WARNINGImproper use of the power cord and plugs can cause a burn, fire or other electric shock hazards. Remove the power cord completely from the line cord strap. Allow unit up to 15 minutes to complete start up period . Press the concentrator circuit breaker reset button located below the power switch . All lights are off when the power switch is On . Audible alert is pulsing . DeVilbiss oxygen concentrators are equipped with a fire mitigating outlet fitting that prevents the propagation of the fire into the unit. Do not service or clean this device while in use with a Patient.

Unit does not operate . Check the output flow by placing the end of the nasal cannula under the surface of a half-full cup of water and look for the bubbles. NOTE This warranty does not obligate DeVilbiss to provide a loaner unit during the time that an oxygen concentrator is undergoing repair.NOTE Replacement components are warranted for the unexpired portion of the original Limited Warranty. In most cases, they are already attached to the oxygen tubing. VitalityMedical.com is for informational purposes only and should not be used as medical advice, to diagnose, or treat patients. Your body requires a steady supply of oxygen to function properly. This is to remove residue that may stain or leave a film on the unit, especially after repeated disinfection. Call us at 800-236-4215 for assistance in locating your Spark parts. Portable RF communications equipment (including peripherals such as antenna cables and external antennas) should be used no closer than 30 cm (12 inches) to any part of the oxygen concentrator, including cables specified by the manufacturer. %PDF-1.6 Filter Replacements for DeVilbiss Oxygen Concentrators, Filter, Final Bacteria - 525DS and 1025DS, Skip to the beginning of the images gallery. The Device is classified as IP21 which means it is protected against finger access to hazardous parts and protected against vertically falling water drops. Supplemental oxygen will increase the amount of oxygen that your body receives. Open flames during oxygen therapy are dangerous and are likely to result in fire or death. Thread the wing nut located on the top of the humidifier bottle to the oxygen outlet so that it is suspended (Figure 2). Keep an eye up this section as we constantly add more products. This device is suitable for use in home and healthcare environments except for near active HF SURGICAL EQUIPMENT and the RF shielded room of an ME SYSTEM for magnetic resonance imaging, where the intensity of Electromagnetic DISTURBANCES is high. Many of these people can benefit from supplemental oxygen therapy. Why Your Physician Prescribed Supplemental Oxygen. G . Use 5.25% chlorine bleach (Clorox Regular Liquid Bleach or equivalent). Check filter door vents and ensure that the openings are not blocked. Intended UseThe DeVilbiss 5 Liter Oxygen Concentrator intended use is to provide supplemental low flow oxygen therapy for patients suffering from COPD, cardiovascular disease, and lung disorders. Warranty Claims SubmissionsThe original purchaser must submit any warranty claim to Drive DeVilbiss or to an Authorized Service Center. Do not remove the concentrator cabinet. Refer to specifications for details regarding parameters tested. Alarm conditions are shown on the LED display. 5330 North 16th Street Phoenix, Arizona 85016Open: Mon-Fri / 8:00AM - 5:00PM PSTPhone: 800-236-4215Fax: 602-279-0952. Mikrobac forte or Terralin Protect) may also be used. Our website requires JavaScript to be enabled to work properly. Unqualified service personnel conduct routine maintenance or servicing. The oxygen concentrator should be located in a well-ventilated area to avoid pollutants or fumes. Filter Types: HEPA Bacteria, Intake, Compressor, Final Bacteria, Cabinet. Attach the oxygen tubing directly to the connector (Figure 1). Never use petroleum or oil-based lotions or salves to avoid the risk of fire and burns. Unit operates . If used with the oxygen accessories, the fire stop device should be located as close to the patient as practicable. 1 . Red Service Required light is illuminated . To ensure you receive the therapeutic amount of oxygen delivery according to your medical condition, the Oxygen Concentrator must: be used only after one or more settings have been individually determined or prescribed for you at your specific activity levels. Smoking during oxygen therapy is dangerous and is likely to result in facial burns or death. 525DD-639: New filter door doesn't require gross particle filter. Taxes and shipping calculated at checkout, Sign up to get the latest on sales, new releases and more , Fax: (540)-296-31578am - 6pm EST Monday - Friday, 12348 North Old Moneta Rd Moneta, VA 24121, 2022 oxygenplusmedical. Use a different wall outlet if the situation occurs again . NOTE A maximum of 50 feet (15 meters) of crush-proof oxygen tubing, plus 7 feet (2.1 meters) of a cannula, plus a bubble humidifier is allowed between the concentrator and the patientNOTE Your healthcare provider should verify the compatibility of the oxygen concentrator and all of the parts used to connect to the patient before use. Ensure the flow meter is properly set to the prescribed number.

If the oxygen. DeVilbiss Customer Service Contact InformationCustomer Service (USA): 800-338-1988International Department: 814-443-4881 /[emailprotected]Ordering Non-Warranty Replacement PartsOrder non-warranty parts and literature from your DeVilbiss provider. Failure to do so may cause an electrical safety hazard. Find all the DeVilbiss 5 Liter Oxygen Concentrator parts you need, including all Respiratory > Oxygen > Concentrators type models for Drive Medical products. WARNINGEnsure the mains power cord is fully inserted into the concentrator connector (230 volt units) and the power cord plug is completely inserted into a fully functioning AC wall outlet. We have parts for legacy machines like the Puritan Bennett 492 or Healthdyne BX-3000 up to the Healthdyne Alliance and Devilbiss MC Series, all the way up to the latest machines like the Respironics EverFlo or Invacare Perfecto and Airsep VisionAire. Look at the flow meter to see that the indicator ball on the flow meter drops to zero. Geriatric, pediatric or any other patient unable to communicate discomfort can require additional monitoring and/or a distributed alarm system to convey the information about the discomfort and/or the medical urgency to the responsible caregiver to avoid harm. We can now offer you new OEM parts, new quality aftermarket parts, as well as quality OxygenPlus reconditioned components that you can trust. After 25 plus years in the business, OxygenPlus has hand picked the best vendors that offer the best quality parts available.

Wait for unit to finish startup period, up to 15 minutes, 1:5 chlorine bleach (5.25%) and water solution, Mikrobac forte, Terralin Protect, Oxygen tubing, tubing connectors, nasal cannula/mask, oxygen outlet connector, humidifier bottle, Outlet Pressure: <15 psi Outlet Flow: 2 LPM, (tested at 70F {21C} only) 0-1500 M (0-4921 ft), Across the voltage range: No degradation of performance, Tested at nominal voltage only: No degradation of performance, Tested at 230V/50Hz only: No degradation of performance, Tested at 230V/60Hz only: No degradation of performance, 41F (5C) to 95F (35C), humidity range of 10% to 95%. The very same quality rebuilt components that we install in our own Oxygen Concentrators that come with up to a full 5 year comprehensive warranty. WARRANTYDeVilbiss Healthcare warrants the DeVilbiss 5 Liter Oxygen Concentrator under the conditions and limitations stated below. New and aftermarket components come with any applicable warranty offered by the manufacturer. This condition will cause no flow out of the device and/or an alarm condition. Filter Door with venting and compartment for optional gross particle filter. It is very important to follow your oxygen prescription. Do not attempt any other maintenance. Quality reconditioned components from OxygenPlus come with a standard 1 year warranty, unless otherwise claimed. Does your "Low Oxygen" light taunt you? The surface temperature of the exhaust vents on the bottom of the unit may exceed 105.8F (41C) under certain conditions. Wipe with dry cloth, or a cloth dampened with water to remove dust . Should this occur, refer to the service manual for additional instructions. No matter what the problem is with your Oxygen Concentrator, we have the quality new and used replacement parts you could need!