Purchased brand new. After having it for a month the check engine light came on. I love my Durango and I have had it for 6 years as I bought it used and I am the second owner.
The vehicle was taken to a dealer, where it diagnosed that the total integrated power module needed to be replaced. I was pulling out of driveway of my employment onto the roadway and accelerating on a completely straight roadway. I have experienced the recall for the electrical panel, along with the egr valve 2 years back and engine stalling in the rain. Brought to mechanic and identified valve seat(s) in the aluminum head(s) have 'disintegrated' and/or 'dropped' causing the valves to slap on acceleration and multiple other catastrophic engine issues. Press the button on the shift lever and hold it Hi there.
Another time vehicle shut down and had to jump lanes and coast to get to side road to stop.
There were previous "investigations" for recall services a few years back, but they were closed out. As vehicle was passing 20-25mph and with no fore-warning, heard loud 'bang' from the engine compartment and vehicle started shaking.
The failure mileage was 100,900. 7 hemi limited used at the end of 2013.
The engine has stalled and would not restart several times late at night. The vehicle was taken to a private mechanic where it was diagnosed that the cam shaft sensor and the egr valve needed to be replaced. Check youtube and google for "Dodge Durango no bus" and you will find this is a major issue with the computer. The radio at times will not pay. After about 6 to 8 minutes of trying it started. After towing the vehicle, to my mechanic, they have since reported what they believe to be as a "catastrophic loss of the engine". An exhaust gas routing tube connects the EGR valve to the intake manifold. I thought it was just a starter going bad or something small.
Normally it would always happen pulling in or backing out of my driveway. Never heard of this part until my vehicle started acting up. They will have to check each wire one by one abd that check up is going to cost 4 hours of work at a cost of approximately $400 before they can run a diagnosis. The manufacturer was not made aware of the failure. Very scary and lucky no traffic behind me since I have to put in park to restart by push button ignition. Is this safe? So I had it towed a second time to the Dodge dealer. The failure recurred several times. Dodge Durango owners have reported 50 This is very dangerous! The contact stated that none of the dealers were able to duplicate the failure, so the vehicle was not repaired.
After doing extensive research and viewing this website, to my surprise I found I wasn't the only owner of this model & year truck having this very same issue. Heres how: 1. 00 to fix it!. Dealership determine there is not a fix as of this point and handed us the keys and told us we would have to wait until there is a fix. I no longer feel safe in this vehicle, I can possibly cause an accident or someone can hit me with all the problems and potentially hurt myself or others with all the recalls and engine problems. 7 v8. I just want to go on record in the event that something detrimental happens to me or my family because of this recognized and publicly documented part failure. The EGR valve is located in the engine compartment (underneath the hood). I have researched the issue after having a tune up on the vehicle with no success.
In my 2012 Dodge Durango it was determined that there is a problem with the total integrated power module which is affecting the way the engine starts and gets fuel to the fuel pump. See
Never hauled heavy loads or trailored. they say my car is not part of the recall and will not pay to fix it. There are times, after sitting at a light or stop sign, when you press the gas to go the gears are slow to engage and actually start moving. This will clean out any sludge or carbon build up in the air intake system. Our service team is available 7 days a week, Monday - Friday from 6 AM to 5 PM PST, Saturday - Sunday 7 AM - 4 PM PST.
2017 Dodge Durango 3.6, 2014 Durango SXT Plus RWD 3.6L White Knuckle--2018 Durango SXT AWD 3.6L Granite Crystal Anodized Pkg, Its on the front left side of motor thanks. I am very disappointed with Dodge as I have read several similar complaints with no resolution. The manufacturer was notified of the failure.
No lights light up on the dash to indicate a problem. the car does not start for them to evan look at it! No fix.
Every fix just feels like a band aid to the manufacturing problems it has.
Bought used, had car less than 12 hours and car stalled while driving thru 90 degree corner on highway. The exterior lights has gone off completely at night without panel light notification. This occurred at 110,000 miles. (photos of my solutions are available. ) The stalling of the vehichle for no apparent reason.
My wife loses all braking and steering power assist when the engine stalls, sometimes when turning across oncoming traffic. It was fine for a week then it did the exact same thing on a very busy road. It would start then die. After getting off the phone with the technician I googled tipm and found all kinds of articles and learned that Chrysler has been struggling with this part on various models for several years. The contact stated that while driving approximately 30 mph, the vehicle stalled and the check engine warning light illuminated.
Our vehicle year make and module fall within the time frame of a stated recall and the same issues in that recall are happening to our vehicle. My Durango has 3 very common issues with lots of other folks that should be recalled: 1.
It stalled on the interstate and my husband was nearly hit. 3.
It use to happen a lot to me. 3. He explained everything well and listened to my concerns.
Someone Broke The Pcv Valve On The Passenger Side Valve Cover And I Cant Figure Out How It Goes Together.
The EGR valve is responsible for taking the gas that comes out of the engine, and sending it through the intake manifold, where the engine can utilize it again. So I paid for the diagnostic and was told it never acted up on the mechanic. This is a health and safety issue that needs to be addressed. It is a good idea to get an air induction (carbon cleaning) service performed every 50,000 miles. Especially if you're driving down the freeway. There was no abnormal function of the vehicle before each incident. . During acceleration the engine will torque over causing the egr pipe to make contact with the battery cable thus causing the plastic sheathing to become chafed. I am trying to locate the EGR Valve on a 2001 Dodge Durango with a 5.9 engine. The vehicle got towed to the deelsrship and after two days they called me back saying that the vehicle is not comunicating with the tipm (totally integrated power module) therefor the can't make a diagnosis. all problems of the 2011 Dodge Durango
See The approximate failure mileage was 120,000 and the current mileage was 133,000. Ultimately have the mechanic played the guessing game, he replaced the egr valve and that had fixed the problem.
There are that many problems with it. The dealer stated that the vehicle needed a new o-ring, lock ring, and the fuel tank needed to be replaced.
I owe almost $8000 on this car, and it will cost at least half of that to fix it. There are a wide variety of reasons why the Check Engine Light (https://www.yourmechanic.com/services/check-engine-light-is-on-inspection) switch may be still on.
Screen on in dash console is just lines.
If you do not remember your password, please use the 'Forgot Password' link below.
Each time I was able to coast to a curb or physically push the vehicle out of traffic.
I was in love with this car but don't know that I want to stick with Dodge after all of these issues. Each time the gasoline tank was at least one quarter full. How Can I Replaced The Pcv Valve On My 2000 Dodge Durango V8?
all problems of the 2013 Dodge Durango Clearly the problem has not been fixed. I have been given a rental car 4 times for an approximate total of 30 days to try to rectify the problems. The technician diagnosed that the throttle needed to be cleaned. The vehicle was repaired but the failure recurred. After several attempts the engine restarted. They must be told to go good for this situation. Time is 0640 hrs, outside temp is approx 30 degrees. This is definitely a recall for this vehicle and should be replaced by Chrysler/Dodge. The entire electrical system has shut down - vehicle had to be towed to the dealership. I had my Durango towed to a Dodge dealer and was told it was the egr valve.
Something went wrong. Nope! Another incident occurred, where the contact returned the engine was on.
But I live in rural wv and we have mountains and curvy roads. 7 hemi has with the blown engine. I was told the totally integrated power module (tipm) was bad and needed to be replaced. The vehicle was taken to an independent mechanic where it was diagnosed that there was an emissions leak and the fuel tank needed to be replaced.
It isn't a safety issue when you lose all power steering, brakes, and pour out oil at highway speeds in the rain?
Over time this chafing will wear through the plastic sheathing and expose the bare copper wire allowing it to come in contact with the metal egr pipe.
Dodge doesn't have the courtesy of calling me back to let me know what's going on. We experienced within 1 week of purchase (March 2011) the frequent stalling out, along with total loss of power brakes and power steering that has been reported by hundreds of 1999 owners. It has happened going 45 mph and as low as 20 mph.
And I would hope that very soon the company would recognize that this is a major problem that needs to be rectified. In the summer it's a death trap that can shut off engine, power steering and brakes in the middle of the freeway. Failing this, the relocation of the pcm with a mounting bracket kit and a harness extension would allow placement of the unit in a cooler location (like right behind the new grille opening). The vehicle was also taken to the dealer suburban Chrysler Dodge Jeep ram of garden city, located at 32850 Ford rd, garden city, mi, 734-421-5700.
I'm contacting you in regards to my 2005 Dodge Durango. There is two recalls in place now for air bag issues. When outside temperature goes beyond 80 degrees fahrenheit, while in motion, the computer has shut off the engine multiple times and a code saying no bus is displayed in the dash for a few seconds. Was wondering how to change the egr valve on a dodge durango and was also wondering on were it is actually located I know that it is on the intake but not sure were thanks, Where is the egr valve located at on the motor, Thursday, February 21st, 2019 AT 5:43 PM
Electrical problem? I would just be driving and it would die. They completed an outstanding recall. Back to service now for 2 weeks. Now, its back into the dealership again!
all problems of the 2005 Dodge Durango Have to close the rear hatch twice for cargo light warning on dash to go out. So I had that replaced along with new spark plugs and wires. I have a great car in the winter. Can someone please look into this with Dodge before someone gets hurt. I have 4 recalls for various issues and none have been fixed due to parts are not readily available.
The repair cost is $1213. 04 Durango slt 4. I learned about tipm and the nearly $1,600 it cost to replace it. Ephraim Chrysler Dodge ram (620 n black horse pike, mt ephraim, NJ 08059 (856) 931-2000) where it was diagnosed that there was a very small evaporative emission system leak. All guages went to zero. I first thought that I had bad fuel and put an fuel additive in the tank to hopefully resolve the problem. Loss of power =no power steering=accident waiting to happen. It has happened to me going 70 mph. The manufacturer was not notified of the failure.
The dealer is now offering to take car back and trade for something else or refund my money (lemon law).
The dealer diagnosed it as the "totally integrated control module" failed. It will not start sometimes and then will not stay running when it does. The motor switch on your heater and air conditioning goes bad when the switch gets stuck in certain positions or will not budge at all. Within 2 weeks of these parts being replaced, my Durango again began stalling out. The approximate failure mileage was 112,680. I can start it, but it sounds like someone is inside with a hammer. . The next day my Durango stalled while I was driving at around 40-45 miles an hour in downtown san diego!! 1999-2022 RockAuto, LLC - Madison, Wisconsin USA. The vehicle would not start.
I restarted my Durango, the check engine light was on, but was able to continue without any further issues. Violent vibrations, tappings and metal to metal sounds, I immediately shut down the engine and drifted off to side of road. 7 hemi has had a vast amount of stalling. Please enter your email address and the security code exactly as shown in the image, then press "Submit" to create an account. The EGR valve helps your vehicle recycle gas. The vehicle was merged to the side and was restarted. I thought it was the starter or battery, and replaced the battery.
All the solutions are related to increasing the airflow to the cpu/pcm area, which chronically overheats due to its location. Our certified mobile mechanics can come to your home or office 7 days a week between 7 AM and 9 PM.
. It isn't worth anything the way it is, and it costs more to fix it than it is probably worth. Please someone help figure this out I saw all of the complaints on line for this exact same problem. So again a week later it did the same thing and so we replaced the electronic throttle control. Please look into this, thank you matt l. Thank you. I have encountered it stalling making turns, driving down the street and at lights. It has occurred at least twice a week in hot weather for a year now, and on may 28th, 2012, it occurred 6 times within 40 miles during a 120 mile trip. Abs has also gone out. 2. . 2. The engine completely shut down and we were not able to start the vehicle using the manual key or key fob-vehicle having it towed.
The failure mileage was about 65,000. 7l hemi 4x4 my vehicle was already running for approx 3-5 minutes, warming up, after I had finished working a full 12-hour night shift. It seems that people have been fortunate not to get into a serious accident and I hope that Dodge figures this out before someone loses their life.
I attempted to start the ignition again, and once again the engine knocked, shaked and had shut down once more. Paul was friendly and on time.
While driving approximately 75 mph, the engine stalled and was unable to restart. You need to shift out of P (Park) and into a gear in order to start driving. Welcome to the best Dodge Durango Forum around, where you can find a great Dodge Durango Wiki and discuss the reliability of the different trim levels including the GT and SRT! The push start button will not always start the vehicle.
Once I was driving about 30-35 mph and I was on a curvy road and it stalled out on me and I about went over the mountain as I could not steer! Your vehicle's EGR valve and solenoid assembly is attached to the front of the right cylinder head.
There seems to be a problem serving the request at this time, {"modules":["unloadOptimization","bandwidthDetection"],"unloadOptimization":{"browsers":{"Firefox":true,"Chrome":true}},"bandwidthDetection":{"url":"https://ir.ebaystatic.com/cr/v/c1/thirtysevens.jpg","maxViews":4,"imgSize":37,"expiry":300000,"timeout":250}}. How do I replace the EGR valve on this Durango. Explains everything well and goes above and beyond. This is a serious matter and if Dodge is not made accountable someone could be hurt. YourMechanic All rights reserved. A plastic, easy installed unit would be the lowest cost solution. This is the 3rd time in the past 3 months I've been taking this vehicle to service for different service issues.
The vehicle was repaired however, the failure recurred. Always the best!
The code tripped was : po6dd mod $00 engine oil pressure control circuit performance/stuck off. The vehicle was taken to mt.
after, still problems for 2m the push start and key fob start has gotten worse. This time he replaced the throttle control module. I would love for Dodge to make this right. I was told they also checked the wiring and could not find anything. We were told to pick up the vehicle and bring it back when the part comes in. we had the vehicle checked over and there was no warning our check engine light on. The engine has gone from automatic to manuel drive without placement in manuel. The same type of issue happens sporadically, regardless of weather or speed. I have reported this failure to Chrysler corp. And they have opened a case number for me, but they have not made any commitment, if they will cover the failure. Sometimes the Durango shifts roughly as you accelerate or decelerate.
While at red lights or stalling while in motion or other stopping reasons.
RockAuto name, logo and, If you do not have an account but would like to check the status of an order, request a change, or report a problem with an order or shipment, please go to our, AWD; 24V VVT Engine. It started with what I thought was just an egr problem about two years ago, and I replaced it. The most recent one is the dash and whipers started going crazy, a sudden smell of burnt wires/electric burn. Tl-the contact owns a 2011 Dodge Durango. All I have to do is pull over and let the computer cool off and it turns on again. During acceleration in the forward direction the vehicle will lose all electrical function and shut down the engine causing the motorist to be stranded in the middle of an intersection or other dangerous section of roadway. In speaking with the technician I found out that it could go completely out at anytime, and if it did, my vehicle would be dead in the water no matter what I was doing. If the EGR valve has gone bad, the car will not pass emissions.
. The contact of the copper wire from the positive battery cable to the metal egr pipe creates a direct short which in turn shuts down the electrical system and any engine control functions. . My options now are: a $2000 engine repair, $4000 engine replacement - or - to 'junk' the vehicle - don't get me started about the damned rust on this thing, either. The manufacturer was not notified of the failure. To not do so is putting our lives and those around us in jeopardy.
Turn on the vehicle. Two checks of the oil level, assured me that there was in fact oil in the engine. Tell us about your vehicle to find the right parts faster, 3 product ratings - 911-236 Dorman Purge Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee 2500, 12 product ratings - OEM 4591250 EGR Valve Tube Seal Gasket O-Ring for Dodge Ram Jeep Chrysler New, 12 product ratings - 2001-2012 Jeep Dodge Chrysler EGR VALVE GASKET TUBE SEAL OEM NEW MOPAR #4591250, 4 product ratings - DODGE RAM CHRYSLER Natural Vacuum Leak Detection Detector NEW OEM MOPAR, 4 product ratings - DORMAN 911-206 EGR & Install Kit for Dakota Durango Ram 1500 Truck Cherokee 4.7L, 2 product ratings - 53032800AA PCV Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee Dakota, 2 product ratings - V373 PCV Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee Dakota Durango, 4 product ratings - V165 PCV Valve New for Ram Truck Van Dodge 1500 2500 Dakota Durango 3500 Magnum, 1 product ratings - 98-08 Dodge Ram 1500 2500 3500 Durango Intrepid EGR Emissions Clip Genuine OEM, 1 product ratings - 07-19 Dodge Jeep Chrysler Ram EMISSION LEAK DETECT PUMP OEM NEW MOPAR GENUINE, 19 product ratings - Dorman: 911-205 - EGR Valve, 4 product ratings - DODGE RAM CHRYSLER JEEP Vapor Canister Seal NEW OEM MOPAR, 4 product ratings - V470 PCV Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee 2500 Durango 300, 2 product ratings - Genuine Mopar Egr Valve 53032509AN, 19 product ratings - 911-213 Dorman Purge Valve New for Town and Country Ram Van Truck Dodge 1500 LHS. I am also having a problem with the fuel tank. It runs down the battery and battery dies every day. It is my understanding that there are hundreds of documented cases regarding this issue in the Chrysler line and nothing has been done to correct the problem. I'm really surprised at the fact that Dodge is not taking care of these issues. Does the intake have to come off? Fast and easy service at your home or office, Backed by 12-month, 12.000-mile guarantee. .
So, needless to say, we don't really have a choice when this part goes out. Also please check out the
What makes this more surprising is the growing number of complaints about this very issue and nothing is being done. I purchased this vehicle for the purpose of transporting my grand kids, and lacrosse players to and from various events.
The contact stated while driving at 65 mph, the engine loss power without warning. To make it worse the vehicle stalled going through an intersection the other day, when I was driving with my 1 year old in the backseat, and we were almost hit, luckily there was an angel looking over us, and the other vehicle stopped just in time. Luckily there were no vehicles behind me, I was able to make it to the next exit. Each time it was in dry, sunny weather with the temperature between 60 and 80 degrees fahrenheit. JavaScript is disabled. The brake pedal will not come back after being pushed to the floor. First incident in may we used the key fob to start the vehicle and the vehicle ran for 5 minutes then shut down. But the case manager never called me.
2022 I noticed there is no metal piece that closes off when you pull the nozzle out. This item has been on backorder and if that's not enough.
The vehicle was taken to a dealer, where it diagnosed that the total integrated power module needed to be replaced. I was pulling out of driveway of my employment onto the roadway and accelerating on a completely straight roadway. I have experienced the recall for the electrical panel, along with the egr valve 2 years back and engine stalling in the rain. Brought to mechanic and identified valve seat(s) in the aluminum head(s) have 'disintegrated' and/or 'dropped' causing the valves to slap on acceleration and multiple other catastrophic engine issues. Press the button on the shift lever and hold it Hi there.
Another time vehicle shut down and had to jump lanes and coast to get to side road to stop.
There were previous "investigations" for recall services a few years back, but they were closed out. As vehicle was passing 20-25mph and with no fore-warning, heard loud 'bang' from the engine compartment and vehicle started shaking.
The failure mileage was 100,900. 7 hemi limited used at the end of 2013.
The engine has stalled and would not restart several times late at night. The vehicle was taken to a private mechanic where it was diagnosed that the cam shaft sensor and the egr valve needed to be replaced. Check youtube and google for "Dodge Durango no bus" and you will find this is a major issue with the computer. The radio at times will not pay. After about 6 to 8 minutes of trying it started. After towing the vehicle, to my mechanic, they have since reported what they believe to be as a "catastrophic loss of the engine". An exhaust gas routing tube connects the EGR valve to the intake manifold. I thought it was just a starter going bad or something small.
Normally it would always happen pulling in or backing out of my driveway. Never heard of this part until my vehicle started acting up. They will have to check each wire one by one abd that check up is going to cost 4 hours of work at a cost of approximately $400 before they can run a diagnosis. The manufacturer was not made aware of the failure. Very scary and lucky no traffic behind me since I have to put in park to restart by push button ignition. Is this safe? So I had it towed a second time to the Dodge dealer. The failure recurred several times. Dodge Durango owners have reported 50 This is very dangerous! The contact stated that none of the dealers were able to duplicate the failure, so the vehicle was not repaired.
After doing extensive research and viewing this website, to my surprise I found I wasn't the only owner of this model & year truck having this very same issue. Heres how: 1. 00 to fix it!. Dealership determine there is not a fix as of this point and handed us the keys and told us we would have to wait until there is a fix. I no longer feel safe in this vehicle, I can possibly cause an accident or someone can hit me with all the problems and potentially hurt myself or others with all the recalls and engine problems. 7 v8. I just want to go on record in the event that something detrimental happens to me or my family because of this recognized and publicly documented part failure. The EGR valve is located in the engine compartment (underneath the hood). I have researched the issue after having a tune up on the vehicle with no success.
In my 2012 Dodge Durango it was determined that there is a problem with the total integrated power module which is affecting the way the engine starts and gets fuel to the fuel pump. See
Never hauled heavy loads or trailored. they say my car is not part of the recall and will not pay to fix it. There are times, after sitting at a light or stop sign, when you press the gas to go the gears are slow to engage and actually start moving. This will clean out any sludge or carbon build up in the air intake system. Our service team is available 7 days a week, Monday - Friday from 6 AM to 5 PM PST, Saturday - Sunday 7 AM - 4 PM PST. 2017 Dodge Durango 3.6, 2014 Durango SXT Plus RWD 3.6L White Knuckle--2018 Durango SXT AWD 3.6L Granite Crystal Anodized Pkg, Its on the front left side of motor thanks. I am very disappointed with Dodge as I have read several similar complaints with no resolution. The manufacturer was notified of the failure.
No lights light up on the dash to indicate a problem. the car does not start for them to evan look at it! No fix.
Every fix just feels like a band aid to the manufacturing problems it has.
Bought used, had car less than 12 hours and car stalled while driving thru 90 degree corner on highway. The exterior lights has gone off completely at night without panel light notification. This occurred at 110,000 miles. (photos of my solutions are available. ) The stalling of the vehichle for no apparent reason.
My wife loses all braking and steering power assist when the engine stalls, sometimes when turning across oncoming traffic. It was fine for a week then it did the exact same thing on a very busy road. It would start then die. After getting off the phone with the technician I googled tipm and found all kinds of articles and learned that Chrysler has been struggling with this part on various models for several years. The contact stated that while driving approximately 30 mph, the vehicle stalled and the check engine warning light illuminated.
Our vehicle year make and module fall within the time frame of a stated recall and the same issues in that recall are happening to our vehicle. My Durango has 3 very common issues with lots of other folks that should be recalled: 1.
It stalled on the interstate and my husband was nearly hit. 3. It use to happen a lot to me. 3. He explained everything well and listened to my concerns.
Someone Broke The Pcv Valve On The Passenger Side Valve Cover And I Cant Figure Out How It Goes Together.
The EGR valve is responsible for taking the gas that comes out of the engine, and sending it through the intake manifold, where the engine can utilize it again. So I paid for the diagnostic and was told it never acted up on the mechanic. This is a health and safety issue that needs to be addressed. It is a good idea to get an air induction (carbon cleaning) service performed every 50,000 miles. Especially if you're driving down the freeway. There was no abnormal function of the vehicle before each incident. . During acceleration the engine will torque over causing the egr pipe to make contact with the battery cable thus causing the plastic sheathing to become chafed. I am trying to locate the EGR Valve on a 2001 Dodge Durango with a 5.9 engine. The vehicle got towed to the deelsrship and after two days they called me back saying that the vehicle is not comunicating with the tipm (totally integrated power module) therefor the can't make a diagnosis. all problems of the 2011 Dodge Durango
See The approximate failure mileage was 120,000 and the current mileage was 133,000. Ultimately have the mechanic played the guessing game, he replaced the egr valve and that had fixed the problem.
There are that many problems with it. The dealer stated that the vehicle needed a new o-ring, lock ring, and the fuel tank needed to be replaced.
I owe almost $8000 on this car, and it will cost at least half of that to fix it. There are a wide variety of reasons why the Check Engine Light (https://www.yourmechanic.com/services/check-engine-light-is-on-inspection) switch may be still on.
Screen on in dash console is just lines.
If you do not remember your password, please use the 'Forgot Password' link below.
Each time I was able to coast to a curb or physically push the vehicle out of traffic.
I was in love with this car but don't know that I want to stick with Dodge after all of these issues. Each time the gasoline tank was at least one quarter full. How Can I Replaced The Pcv Valve On My 2000 Dodge Durango V8?
all problems of the 2013 Dodge Durango Clearly the problem has not been fixed. I have been given a rental car 4 times for an approximate total of 30 days to try to rectify the problems. The technician diagnosed that the throttle needed to be cleaned. The vehicle was repaired but the failure recurred. After several attempts the engine restarted. They must be told to go good for this situation. Time is 0640 hrs, outside temp is approx 30 degrees. This is definitely a recall for this vehicle and should be replaced by Chrysler/Dodge. The entire electrical system has shut down - vehicle had to be towed to the dealership. I had my Durango towed to a Dodge dealer and was told it was the egr valve.
Something went wrong. Nope! Another incident occurred, where the contact returned the engine was on.
But I live in rural wv and we have mountains and curvy roads. 7 hemi has with the blown engine. I was told the totally integrated power module (tipm) was bad and needed to be replaced. The vehicle was taken to an independent mechanic where it was diagnosed that there was an emissions leak and the fuel tank needed to be replaced.
It isn't a safety issue when you lose all power steering, brakes, and pour out oil at highway speeds in the rain?
Over time this chafing will wear through the plastic sheathing and expose the bare copper wire allowing it to come in contact with the metal egr pipe.
Dodge doesn't have the courtesy of calling me back to let me know what's going on. We experienced within 1 week of purchase (March 2011) the frequent stalling out, along with total loss of power brakes and power steering that has been reported by hundreds of 1999 owners. It has happened going 45 mph and as low as 20 mph.
And I would hope that very soon the company would recognize that this is a major problem that needs to be rectified. In the summer it's a death trap that can shut off engine, power steering and brakes in the middle of the freeway. Failing this, the relocation of the pcm with a mounting bracket kit and a harness extension would allow placement of the unit in a cooler location (like right behind the new grille opening). The vehicle was also taken to the dealer suburban Chrysler Dodge Jeep ram of garden city, located at 32850 Ford rd, garden city, mi, 734-421-5700.
I'm contacting you in regards to my 2005 Dodge Durango. There is two recalls in place now for air bag issues. When outside temperature goes beyond 80 degrees fahrenheit, while in motion, the computer has shut off the engine multiple times and a code saying no bus is displayed in the dash for a few seconds. Was wondering how to change the egr valve on a dodge durango and was also wondering on were it is actually located I know that it is on the intake but not sure were thanks, Where is the egr valve located at on the motor, Thursday, February 21st, 2019 AT 5:43 PM
Electrical problem? I would just be driving and it would die. They completed an outstanding recall. Back to service now for 2 weeks. Now, its back into the dealership again!
all problems of the 2005 Dodge Durango Have to close the rear hatch twice for cargo light warning on dash to go out. So I had that replaced along with new spark plugs and wires. I have a great car in the winter. Can someone please look into this with Dodge before someone gets hurt. I have 4 recalls for various issues and none have been fixed due to parts are not readily available.
The repair cost is $1213. 04 Durango slt 4. I learned about tipm and the nearly $1,600 it cost to replace it. Ephraim Chrysler Dodge ram (620 n black horse pike, mt ephraim, NJ 08059 (856) 931-2000) where it was diagnosed that there was a very small evaporative emission system leak. All guages went to zero. I first thought that I had bad fuel and put an fuel additive in the tank to hopefully resolve the problem. Loss of power =no power steering=accident waiting to happen. It has happened to me going 70 mph. The manufacturer was not notified of the failure.
The dealer is now offering to take car back and trade for something else or refund my money (lemon law).
The dealer diagnosed it as the "totally integrated control module" failed. It will not start sometimes and then will not stay running when it does. The motor switch on your heater and air conditioning goes bad when the switch gets stuck in certain positions or will not budge at all. Within 2 weeks of these parts being replaced, my Durango again began stalling out. The approximate failure mileage was 112,680. I can start it, but it sounds like someone is inside with a hammer. . The next day my Durango stalled while I was driving at around 40-45 miles an hour in downtown san diego!! 1999-2022 RockAuto, LLC - Madison, Wisconsin USA. The vehicle would not start.
I restarted my Durango, the check engine light was on, but was able to continue without any further issues. Violent vibrations, tappings and metal to metal sounds, I immediately shut down the engine and drifted off to side of road. 7 hemi has had a vast amount of stalling. Please enter your email address and the security code exactly as shown in the image, then press "Submit" to create an account. The EGR valve helps your vehicle recycle gas. The vehicle was merged to the side and was restarted. I thought it was the starter or battery, and replaced the battery.
All the solutions are related to increasing the airflow to the cpu/pcm area, which chronically overheats due to its location. Our certified mobile mechanics can come to your home or office 7 days a week between 7 AM and 9 PM.
. It isn't worth anything the way it is, and it costs more to fix it than it is probably worth. Please someone help figure this out I saw all of the complaints on line for this exact same problem. So again a week later it did the same thing and so we replaced the electronic throttle control. Please look into this, thank you matt l. Thank you. I have encountered it stalling making turns, driving down the street and at lights. It has occurred at least twice a week in hot weather for a year now, and on may 28th, 2012, it occurred 6 times within 40 miles during a 120 mile trip. Abs has also gone out. 2. . 2. The engine completely shut down and we were not able to start the vehicle using the manual key or key fob-vehicle having it towed.
The failure mileage was about 65,000. 7l hemi 4x4 my vehicle was already running for approx 3-5 minutes, warming up, after I had finished working a full 12-hour night shift. It seems that people have been fortunate not to get into a serious accident and I hope that Dodge figures this out before someone loses their life.
I attempted to start the ignition again, and once again the engine knocked, shaked and had shut down once more. Paul was friendly and on time.
While driving approximately 75 mph, the engine stalled and was unable to restart. You need to shift out of P (Park) and into a gear in order to start driving. Welcome to the best Dodge Durango Forum around, where you can find a great Dodge Durango Wiki and discuss the reliability of the different trim levels including the GT and SRT! The push start button will not always start the vehicle.
Once I was driving about 30-35 mph and I was on a curvy road and it stalled out on me and I about went over the mountain as I could not steer! Your vehicle's EGR valve and solenoid assembly is attached to the front of the right cylinder head.
There seems to be a problem serving the request at this time, {"modules":["unloadOptimization","bandwidthDetection"],"unloadOptimization":{"browsers":{"Firefox":true,"Chrome":true}},"bandwidthDetection":{"url":"https://ir.ebaystatic.com/cr/v/c1/thirtysevens.jpg","maxViews":4,"imgSize":37,"expiry":300000,"timeout":250}}. How do I replace the EGR valve on this Durango. Explains everything well and goes above and beyond. This is a serious matter and if Dodge is not made accountable someone could be hurt. YourMechanic All rights reserved. A plastic, easy installed unit would be the lowest cost solution. This is the 3rd time in the past 3 months I've been taking this vehicle to service for different service issues.
The vehicle was repaired however, the failure recurred. Always the best!
The code tripped was : po6dd mod $00 engine oil pressure control circuit performance/stuck off. The vehicle was taken to mt.
after, still problems for 2m the push start and key fob start has gotten worse. This time he replaced the throttle control module. I would love for Dodge to make this right. I was told they also checked the wiring and could not find anything. We were told to pick up the vehicle and bring it back when the part comes in. we had the vehicle checked over and there was no warning our check engine light on. The engine has gone from automatic to manuel drive without placement in manuel. The same type of issue happens sporadically, regardless of weather or speed. I have reported this failure to Chrysler corp. And they have opened a case number for me, but they have not made any commitment, if they will cover the failure. Sometimes the Durango shifts roughly as you accelerate or decelerate.
While at red lights or stalling while in motion or other stopping reasons.
RockAuto name, logo and, If you do not have an account but would like to check the status of an order, request a change, or report a problem with an order or shipment, please go to our, AWD; 24V VVT Engine. It started with what I thought was just an egr problem about two years ago, and I replaced it. The most recent one is the dash and whipers started going crazy, a sudden smell of burnt wires/electric burn. Tl-the contact owns a 2011 Dodge Durango. All I have to do is pull over and let the computer cool off and it turns on again. During acceleration in the forward direction the vehicle will lose all electrical function and shut down the engine causing the motorist to be stranded in the middle of an intersection or other dangerous section of roadway. In speaking with the technician I found out that it could go completely out at anytime, and if it did, my vehicle would be dead in the water no matter what I was doing. If the EGR valve has gone bad, the car will not pass emissions.
. The contact of the copper wire from the positive battery cable to the metal egr pipe creates a direct short which in turn shuts down the electrical system and any engine control functions. . My options now are: a $2000 engine repair, $4000 engine replacement - or - to 'junk' the vehicle - don't get me started about the damned rust on this thing, either. The manufacturer was not notified of the failure. To not do so is putting our lives and those around us in jeopardy.
Turn on the vehicle. Two checks of the oil level, assured me that there was in fact oil in the engine. Tell us about your vehicle to find the right parts faster, 3 product ratings - 911-236 Dorman Purge Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee 2500, 12 product ratings - OEM 4591250 EGR Valve Tube Seal Gasket O-Ring for Dodge Ram Jeep Chrysler New, 12 product ratings - 2001-2012 Jeep Dodge Chrysler EGR VALVE GASKET TUBE SEAL OEM NEW MOPAR #4591250, 4 product ratings - DODGE RAM CHRYSLER Natural Vacuum Leak Detection Detector NEW OEM MOPAR, 4 product ratings - DORMAN 911-206 EGR & Install Kit for Dakota Durango Ram 1500 Truck Cherokee 4.7L, 2 product ratings - 53032800AA PCV Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee Dakota, 2 product ratings - V373 PCV Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee Dakota Durango, 4 product ratings - V165 PCV Valve New for Ram Truck Van Dodge 1500 2500 Dakota Durango 3500 Magnum, 1 product ratings - 98-08 Dodge Ram 1500 2500 3500 Durango Intrepid EGR Emissions Clip Genuine OEM, 1 product ratings - 07-19 Dodge Jeep Chrysler Ram EMISSION LEAK DETECT PUMP OEM NEW MOPAR GENUINE, 19 product ratings - Dorman: 911-205 - EGR Valve, 4 product ratings - DODGE RAM CHRYSLER JEEP Vapor Canister Seal NEW OEM MOPAR, 4 product ratings - V470 PCV Valve New for Ram Truck Dodge 1500 Jeep Grand Cherokee 2500 Durango 300, 2 product ratings - Genuine Mopar Egr Valve 53032509AN, 19 product ratings - 911-213 Dorman Purge Valve New for Town and Country Ram Van Truck Dodge 1500 LHS. I am also having a problem with the fuel tank. It runs down the battery and battery dies every day. It is my understanding that there are hundreds of documented cases regarding this issue in the Chrysler line and nothing has been done to correct the problem. I'm really surprised at the fact that Dodge is not taking care of these issues. Does the intake have to come off? Fast and easy service at your home or office, Backed by 12-month, 12.000-mile guarantee. .
So, needless to say, we don't really have a choice when this part goes out. Also please check out the
What makes this more surprising is the growing number of complaints about this very issue and nothing is being done. I purchased this vehicle for the purpose of transporting my grand kids, and lacrosse players to and from various events.
The contact stated while driving at 65 mph, the engine loss power without warning. To make it worse the vehicle stalled going through an intersection the other day, when I was driving with my 1 year old in the backseat, and we were almost hit, luckily there was an angel looking over us, and the other vehicle stopped just in time. Luckily there were no vehicles behind me, I was able to make it to the next exit. Each time it was in dry, sunny weather with the temperature between 60 and 80 degrees fahrenheit. JavaScript is disabled. The brake pedal will not come back after being pushed to the floor. First incident in may we used the key fob to start the vehicle and the vehicle ran for 5 minutes then shut down. But the case manager never called me.
2022 I noticed there is no metal piece that closes off when you pull the nozzle out. This item has been on backorder and if that's not enough.